Rockwell-automation 1492-PLTKIT Plotter Kit - User Manual Manuel d'utilisateur télécharger pdf (Page 53)

Chapter

Troubleshooting and Maintenance

Chapter Objectives

This chapter describes how to:

 Troubleshoot the marking system

 Perform routine maintenance

 Clean the plotter pens

 Technical Specifications

Using the Troubleshooting

Chart

Table 4.A is a troubleshooting chart. This chart lists the most common

operating problems, probable causes, and steps to correct the problem. If you

encounter a problem that is not listed in the table, contact

Rockwell Automation Technical Support at (440) 646-3434,

options: 3, 2, 4, 2, 5.

Required Equipment

A voltmeter is required for verifying that the correct voltage is supplied to the

plotter. The voltmeter is also required for verifying the correct

communications cable configuration.

1 2 ... 48 49 50 51 52 53 54 55 56 57 58 ... 61 62

Plotter Kit 1
Important User Information 2
Table of Contents 3
Troubleshooting and 4
Maintenance—4 4
Overview of this Manual 5
Intended Audience 6
Conventions 6
Marking System Description 7
Marker Cards 8
GND TB1 TB2GNDGND 8
Marker Types 9
ClearTools Software 12
Accessories 13
Marker Card Inlay 16
1492-MW5-21 Inlay needed 16
1492-MW6-21 No inlay needed 16
1492-MW7-21 No inlay needed 16
Initial Setup 17
Installing the Plotter Driver 18
“Open” and then with “OK” 19
Click on “Yes” 20
Initial Setup 2-5 21
1492-PLTKIT Series E within 22
Windows Vista 22
Initial Setup 2-7 23
1492-PLTKIT 23
2-8 Initial Setup 24
Initial Setup 2-9 25
Panel > System.) 26
Initial Setup 2-11 27
1492-PLTKIT Series E within 28
Windows XP 28
Initial Setup 2-13 29
1492-PLTKIT Series E 30
Initial Setup 2-15 31
“Device Functions” list 32
Initial Setup 2-17 33
2-18 Initial Setup 34
Installing a Pen in the Pen 35
Introduction 36
Switching to Plot Mode 36
Initial Setup 2-21 37
Printing/Plotting 38
Mapping to Plotter: 38
General Calibration: 39
Adjusting Marker Type 40
Initial Setup 2-25 41
2-26 Initial Setup 42
Plotting 43
Plotting Multiple Cards 43
Multiples of the same card: 44
Initial Setup 2-29 45
2-30 Initial Setup 46
Initial Setup 2-31 47
2-32 Initial Setup 48
Operation of Plotter 49
Pen Station Open/Close Button 50
Stop/View Button 50
Chapter Objectives 53
Using the Troubleshooting 53
Required Equipment 53
Plotter Maintenance 54
Cleaning Plotter 54
Pen Maintenance 55
Technical Specifications 56
Appendix A 57
For Plotter Plates with 57
Adhesive Strips 57
1492-PLOTPLT 57
Series A 57
A-2 Appendix A 58

Commentaires sur ces manuels

Pas de commentaire

Rockwell-automation 1492-PLTKIT Plotter Kit - User Manual Manuel d'utilisateur Page 53

Commentaires sur ces manuels

Produits connexes et manuels pour Équipement Rockwell-automation 1492-PLTKIT Plotter Kit - User Manual